Mathematical Models for the Appointment of the Chlorine Magnesia Composition

The article contains the results of a three-factor experiment. The dependence between the compressive strength, hygroscopic, and the composition ratio of magnesium oxychloride cement was obtained. The ratio between the main components of magnesium oxychloride: magnesium oxide, magnesium chloride and water were used as factors instead of the density of the sealer and its quantity. The values of the responses were received empirically. Statistical analysis of actual data allowed to obtain the mathematical model of properties. Check of adequacy of mathematical models showed that the actual values of strength and water absorption correlate well with the calculated values. This allows assigning compositions of magnesium oxychloride cement of various kinds of magnesia with desired properties and avoiding the formation of efflorescence and cracking of magnesia materials. The content of magnesium oxide in magnesia, required strength and hygroscopic must be the initial data.

Keywords

magnesia astringent; bischofite; strength; hygroscopic.

References

1. Falikman W.R., Sorokin Ju.W., Weiner A.Ja., Baschlykow N.F., Bernstein L.G., Smirnow W.A. Magnesium Caustic Dolomite Concrete. Industrieboden. 5 Internationales Kolloquium, Ostfildern/Stuttgart. S.s., 21-23 Januar, 2003.
2. Karimi Y., Monshi A. Effect of Magnesium Chloride Concentrations on the Properties of Magnesium Oxychloride Cement for Nano SiC Composite Purposes. Ceramics International, 2011, no. 37, pp. 2405-2410. DOI: 10.1016/j.ceramint.2011.05.082
3. Misra A.K., Mathur R. Magnesium Oxychloride Cement Concrete. Bulletin of Materials Science Indian Academy of Sciences, vol. 30, no. 3, 2007, pp. 239-246. DOI: 10.1007/s12034-007-0043-4
4. Ramachandran V.S., Keyker K.P., Moean Rai [The Chlorine Magnesia Cement Produced from Calcined Dolomite]. Russian Journal of Applied Chemistry, 1967, vol. 40, no. 8, pp. 1687-1695. (in Russian)
5. Fedorov N.F., Andreev M.A. [Calcined Magnesia Chloride Cement]. Journal Cement and Its Applications, 2006, no. 5, pp. 76-78. (in Russian)
6. Shelikhov N.S., Rakhimov R.Z. [Integrated Use of Carbonate Raw Materials for the Poduction of Building Materials]. Stroitel'nye Materialy, 2006, no. 9, pp. 42-44. (in Russian)
7. Chernykh T.N., Orlov A.A., Kramar L.Ya., et al. [Energy Savings in the Preparation of Magnesia Astringent for Building Purpose]. Stroitel'nye Materialy, 2011, no. 8 (680), pp. 58-61. (in Russian)
8. Nosov A.V., Chernykh T.N., Kramar L.Ya. [The Effectiveness of Various Additives, Enhancers During Firing Dolomite]. Stroitel'nye Materialy, 2014, no. 6, pp. 71-76. (in Russian)
9. Gorshkov V.S., Timashev V.V., Savel'ev V.G. Metody fiziko-khimicheskogo analiza vyazhushchikh veshchestv [Methods of Physicochemical Analysis Binders]. Moscow, Nauka, 1981. (in Russian)
10. Adler Yu.P. Vvedenie v planirovanie eksperimenta [Introduction to Experimental Design]. Moscow, Metallurgy, 1968. (in Russian)
11. Vinarskiy M.S., Lur'e M.V. Planirovanie eksperimenta v tekhnologicheskikh issledovaniyakh [Experimental Design in Technological Research]. Kiev, Equipment, 1975. (in Russian)
12. Shestakov A.L., Sviridyuk G.A., Butakova M.D. The Mathematical Modelling of the Production of Construction Mixtures With Prescribed Properties. Bulletin of the South Ural State University. Series: Mathematical Modelling, Programming and Computer Software, 2015, vol. 8, no. 1, pp. 100-110.